[Public-List] Opening Ports

Darcy Haldeman -MDH- darcy.haldeman at maryland.gov
Mon Jul 2 06:19:16 PDT 2018


Thanks, I've seen them and yes, a little pricey.  I was hoping there was a
more reasonable alternative. At the Boatshow New Found Metals said they
could make stainless ones, but they would need 4-5 boats to order.

On Mon, Jul 2, 2018 at 9:12 AM, Wes Gardner via Public-List <
public-list at lists.alberg30.org> wrote:

> Hi Darcy,
>
> If you're speaking of the small oval ports up front, my boat came with
> them. There's been some discussion on whether or not they were "factory"
> options.  I think they were.  I believe what's available now is through
> Spartan Marine...get ready for a bit of sticker shock.  I wrote an article
> for the club paper a while ago regarding replacing the gaskets on mine.
> You may get lucky and find some of the old Wilcox-Crittenden ports in
> someone's stash.
>
> Good luck with your search!
>
> My boat, #196 came to me with three opening and one fixed oval ports.  I
> can't say for sure, but it appears as if they are original. The exterior
> trim matches the larger fixed ports in both profile, material and means of
> fastening, using small slotted bolts with acorn nuts on the inside. One of
> the opening ports started to leak at the rubber gasket. It also has one
> “leg” of the hinge broken off. None of them leak where they are fitted to
> the cabin house sides. The one that leaked is over my wife's bunk. (Photo
> “Opening Port”)
>
>
>
> Other folks have reported that mine are oversized and not original...could
> be, while yet others have reported that they have some that are exactly
> like mine ... while still others have said they believe our boats didn't
> come with opening ports. Truth be told, I don't know. I DO know that over
> the entire production run, there are many variations, some subtle, some not
> so on the overall fit and finish of our sturdy little boats.
>
>
>
> My education on ports for the A30 began by reading what has been posted on
> the website regarding ports in general...mostly dealing with rebedding and
> reglazing the large ones. Good stuff, that! However, I thought I had read
> somewhere about gasket material for the opening ports but I couldn't find
> anything when I went looking. I then contacted the good folks at Spartan
> Marine who got back to me in a prompt and professional manner.
> Unfortunately, they were unable to identify the manufacturer of my ports.
> Spartan does make a beautifully crafted bronze opening oval port that will
> fit nicely and with that level of craftsmanship comes a significant price.
> I also did a search on EBay for Wilcox-Crittenden oval ports. I pretty much
> came up blank. By the way, mine do not have the stylized WC logo anywhere
> on them. My assumption is mine are cast aluminum as a magnet does not
> stick. (Photo “Opening Port Outside”)
>
>
>
> And why was I writing this? Oh yes, the leak over my wife's bunk. The
> portlight in question leaked at the rubber gasket which might also be
> original. The rubber was compressed out of shape and had lost its
> elasticity. Don't get me wrong, I'm not complaining! If the new one lasts
> half that long, I'll be a happy boat owner. (Photo “Old Gasket”)
>
>
>
>  My first query was to Taco Marine, they have a lot of good stuff but alas,
> not quite what I was looking for. I stumbled on a product by Wefco that has
> proven to be just the thing. It is 1/4" square in section with a
> cylindrical hollow core.  Isn't it funny how once you know what you're
> looking for, it seems to turn up most everywhere. I ordered it by the foot
> from Defender. The replacement of the old with the new was simple - the old
> came right out of the channel that's cast into the frame of the port and
> the new gasket material was press-fitted in dry sort of pushing back on
> itself a little so as not to stretch it. The joint is a simple butt joint
> at the top. Could you mitre-cut the joint? Sure. Could you set the gasket
> material in rubber cement or similar? Sure. My wife says it doesn't leak so
> far the way it is.
>
>
> On Mon, Jul 2, 2018 at 8:24 AM, Darcy Haldeman -MDH- via Public-List <
> public-list at lists.alberg30.org> wrote:
>
> > Has anyone installed opening ports?
> >
> > --
> > Darcy Haldeman
> > Administrative Specialist
> > Somerset County Health Department
> > 443-523-1781
> > 410-651-3189 FAX
> >
> > CONFIDENTIALITY NOTICE:
> > This message and the accompanying documents are intended only for the use
> > of the individual or entity to which they are addressed and may contain
> > information that is privileged, the disclosure of which is governed by 42
> > CFR, Part 2, the Health Insurance Portability and Accountability Act
> > (HIPPA) and other applicable Federal and State law. The authorized
> > recipient of this information is prohibited from disclosing this
> > information to any other party unless required to do so by law or
> > regulation, and is required to destroy the information after its stated
> > need has been fulfilled. If the reader of this email is not the intended
> > recipient, you are hereby notified that you are strictly prohibited from
> > reading, disseminating, distributing, or copying this communication. If
> you
> > have received this email in error, please notify the sender immediately
> and
> > destroy the original transmission.
> >
> > --
> > NOTICE: This message and the accompanying documents are intended only for
> > the use of the individual or entity to which they are addressed and may
> > contain information that is privileged, or exempt from disclosure under
> > applicable law. If the reader of this email is not the intended
> recipient,
> > you are hereby notified that you are strictly prohibited from reading,
> > disseminating, distributing, or copying this communication. If you have
> > received this email in error, please notify the sender immediately and
> > destroy the original transmission.
> > _______________________________________________
> > These businesses support your Association:
> > http://www.alberg30.org/store/A30supporters.html
> > Please support them.
> > _______________________________________________
> > Public-List mailing list
> > Public-List at lists.alberg30.org
> > http://lists.alberg30.org/listinfo.cgi/public-list-alberg30.org
> >
> _______________________________________________
> These businesses support your Association:
> http://www.alberg30.org/store/A30supporters.html
> Please support them.
> _______________________________________________
> Public-List mailing list
> Public-List at lists.alberg30.org
> http://lists.alberg30.org/listinfo.cgi/public-list-alberg30.org
>



-- 
Darcy Haldeman
Administrative Specialist
Somerset County Health Department
443-523-1781
410-651-3189 FAX

CONFIDENTIALITY NOTICE:
This message and the accompanying documents are intended only for the use
of the individual or entity to which they are addressed and may contain
information that is privileged, the disclosure of which is governed by 42
CFR, Part 2, the Health Insurance Portability and Accountability Act
(HIPPA) and other applicable Federal and State law. The authorized
recipient of this information is prohibited from disclosing this
information to any other party unless required to do so by law or
regulation, and is required to destroy the information after its stated
need has been fulfilled. If the reader of this email is not the intended
recipient, you are hereby notified that you are strictly prohibited from
reading, disseminating, distributing, or copying this communication. If you
have received this email in error, please notify the sender immediately and
destroy the original transmission.

-- 
NOTICE: This message and the accompanying documents are intended only for 
the use of the individual or entity to which they are addressed and may 
contain information that is privileged, or exempt from disclosure under 
applicable law. If the reader of this email is not the intended recipient, 
you are hereby notified that you are strictly prohibited from reading, 
disseminating, distributing, or copying this communication. If you have 
received this email in error, please notify the sender immediately and 
destroy the original transmission. 


More information about the Public-List mailing list